Open Access Open Access  Restricted Access Subscription Access

Partial Replacement of Metakaolin

V. P Valar

Abstract


By substituting a suitable material, typically some supplementary cementitious material like metakaolin, as the primary component of concrete, construction can be made more cost-effective. Cement is the main component of concrete. High strength concrete mix is preferred to conventional concrete to meet the rising demand for highway bridges, high-rise buildings, and other structures. The expansion of metakaolin in high strength cement can achieve immense changes concerning economy as well as effectiveness of development. The goal of this research is to figure out how much metakaolin is needed to make stronger concrete with more efficiency. The substantial blend utilized is of M60 grade and concrete division was to some degree supplanted with 10, 12.5, 15, 17.5 and 20%metakaolin by mass. The specimens were subjected to tests of compression, split tensile, and flexural strength, and the results indicate that the optimal metakaolin content is 15%.


Full Text:

PDF

References


Ramezanian pour, H. B. Jovein (2012). Influence of metakaol n as supplementary cementing material on strength and durability of concretes. Construction and Building Materials.2013. 30: 470–479p.

Nadeem, S. A. Memonb, T. Y. Lo (2013). Mechanical performance, durability, qualitative and quantitative analysis of microstructure of fly ash and metakaol in mortar at elevated temperatures. Construction andBuilding Materials. 2013.38:338– 347p.

Patil, P. D. Kumbhar (2012). Strength and durability properties of high performance concrete incorporating high reactivity metakaolin. International Journal of Modern Engineering Research. 2012.

2(3):1099-1104p.

L. Lee, R. Huang, W. T. Lin, and T. L. Weng (2012). Establishment of the durability indices for cement based composite containing supplementary cementitious materials. Materials and Design. 2012.37:28–39p.

Guneyisi, M. Gesoglu, S. Karaoglu, and K. Mermerdas (2012). Strength, permeability and shrinkage cracking of silica fume and metakaolin concretes. Construction and Building Materials. 2012. 34:120–130p.

Guneyisi, M. Gesoglu, F. Karaboga, and K.Mermerdas (2013).Corrosion behavior of reinforcing steel embedded in chloride contaminated concretes with and without metakaolin. Composites B. 2013.45:1288–1295p.

H. Paiva, A. Velosa, P. Cachim, and V. M.Ferreira (2012). Effect of metakaolin dispersion on the fresh and hardened state properties of concrete. Cement and Concrete Research. 2012. 42: 607–

612p.

M. I. Khan and A. M. Alhozaimy (2011). Properties of natural pozzolan and its potential utilization in environmental friendly concrete.


Refbacks

  • There are currently no refbacks.